HP-41CV power problem

I have an HP-41CV exhibiting a strange problem. First, it is difficult to turn on. The on key must be depressed several times, perhaps even holding it down for a few seconds. I suspected this was simply a contact problem - however, once it is on, it powers off by itself after about 10 seconds. New batteries, memory clear, and no flags set. Any advice is appreciated. The power button problem has been there for a while, but the auto-power-down problem just came up.



There is a capacitor on the mother board that can cause this problem. The capacitor is designated C2 and the long and short of it is that if your display driver assembly is covered in epoxy the you use a 470 pf cap and if it is covered with a plastic cover you use a 0.01 uf cap. Check that you have the right cap and that it is good.

The following is from the service manual.

There are differences in appearance as well as in the automatic
(10 minute) time-out featUre. This is primarily due to a change 1n ~
capacitor of the logic board from .01 uf to 470 pf .

Revision "G" uses 470 pf/D160-057l

Revision "F" uses .01 uf/0160-3914

The difference in appearance can be seen by looking at the covering
over the display hybrids.

Revision "G" is covered by epoxy .

Revision "Fit is covered by a plastic cap .

If the value of capacitor is interchanged with revi sion of the display driver assembly the following symptoms occur:

1. Revision "Gil with 470 pf

Frequency = 8.3 KHZ

Timeout = 9 mi nutes

Display = OK

2. Revision "G" with . 01 uf

Frequency = 435 KHZ

Timeout - , •

Display = fli ckering

3. Revision "F" with . 01 uf

Frequency = 6.3 KHZ

Timeout - 12 minutes

Di spl ay = OK

4. Revision "F" with 470 pf

Frequency - 110 KHZ

Timeout - 40 seconds

Display - OK


Thanks for the detailed response. Don't know when or if I'll have the time to take this thing apart and fix, but I'll know what to do then thanks to your good work.

Best regards,

Possibly Related Threads...
Thread Author Replies Views Last Post
  HP 41CV Repairs William Mabotja 3 1,331 11-20-2013, 04:45 PM
Last Post: Mike Powell
  "Packing" syndrome of my HP-41CV PGILLET 12 2,889 11-03-2013, 02:46 PM
Last Post: Hans Holzach
  HP Prime Save Power Turn Off Not Working Timothy Roche 12 3,508 10-27-2013, 01:41 PM
Last Post: Michael de Estrada
  Low power warning for HP-15C LE and batteries Nick_S 1 1,166 09-16-2013, 09:34 AM
Last Post: Hans Brueggemann
  HP 9845 option 200 power supply Dave F 2 1,337 05-30-2013, 08:10 AM
Last Post: Dave F
  HP-41CV - A Walk Down Memory Lane Tom Lewis 9 2,293 03-18-2013, 11:14 PM
Last Post: BShoring
  HP-87 power supply repair philippe_elie 0 783 11-18-2012, 11:12 AM
Last Post: philippe_elie
  HP-48: extract coefficient of power series Thomas Klemm 3 1,267 10-21-2012, 11:42 PM
Last Post: Han
  What power adaptor does an HP-65 use? Robert Morton 3 1,191 09-30-2012, 02:32 PM
Last Post: Kees Bouw
  HP-41CV layout vs Voyager's, 35s Ben Huntsman 17 3,771 09-17-2012, 05:30 PM
Last Post: Luiz C. Vieira (Brazil)

Forum Jump: