HP19BII - how to fix the battery compartment
#1

I've had my HP19BII for almost 10years and have managed with a broken battery compartment for about three years by using strong carpet tape...unfortunately the tape gave way today and the last remnant of one of the plastic edges needed to hold the battery cover in place snapped off. New tape on its own was not strong enough to hold the cover.

The battery compartment on the HP19BII is on the uppermost right hand side edge, my uppermost edge of the battery cover still slides into place however the lower edge has nothing left to slide into.

To fix, I have used a small washer and a woodscrew (10 milimetre in length and 5 milimetre head) which I have screwed into the calculator case in the gap where the missing edge has snapped off. I inserted the batteries and held the cover in place whilst I tightened the screw and washer so they overlapped the battery cover but held it in place.

To create the hole in the case, I used a very sharp nail as a nail punch, held the HP19BII in between my knees (to allow movement in case I hit it too hard) and tapped the nail into the plastic until it was fully pierced. I then wriggled the nail around to make the hole big enough for the screw to enter. NOTE - don't use a long screw as it might reach too far inside and damage the electronics.

Works a treat for me! Hope this can help someone else!

P.S. I will try and add a photo, hope that works too!

#2

Eddieuk,

just yesterday someone posted a solution that might be helpful to solve your problem too!

http://groups.google.to/group/comp.sys.hp48/browse_thread/thread/15e313dc7605875c#

Best regards,

Peter A. Gebhardt

#3

I found some 2 part epoxy plastic cement that was strong enough to repair the battery door on a camera. When it was partly hardened I shaped it to fit, and extend the edge of the plastic. The repair held until some other faults damaged the camera. It did cling well and was strong enough. It was at Home Depot. Sam

#4

Photo as promised.



Possibly Related Threads…
Thread Author Replies Views Last Post
  50g battery compartment Jan 3 1,506 11-04-2013, 02:46 AM
Last Post: Derek Walker (UK)
  SCIOVR and ENGOVR in FIX mode Andrew Nikitin 5 1,781 07-02-2013, 04:46 AM
Last Post: Victor Koechli
  HP19BII Version 2 Frank 6 1,921 02-21-2013, 12:06 PM
Last Post: Dave Britten
  A temporary "fix", the Casio Prism (fx-CG10) LHH 5 2,001 08-25-2012, 07:39 PM
Last Post: LHH
  Craigslist find and fix - HP 19C Matt Fegenbush 12 3,654 08-13-2012, 02:57 PM
Last Post: Matt Fegenbush
  aOT--Battery/battery contact care advice needed Matt Agajanian 0 1,118 04-24-2012, 07:35 PM
Last Post: Matt Agajanian
  Keyboard fix for the HP 15C LE Jeff Raines 2 1,122 03-31-2012, 12:49 AM
Last Post: Jeff Raines
  Just a thought I had--a 35S Trig fix Matt Agajanian 62 11,901 03-26-2012, 10:40 AM
Last Post: bill platt
  15C-LE Overdue for a fix? Matt Agajanian 7 2,134 03-24-2012, 01:46 PM
Last Post: nina scholz
  Keyboard fix for the HP 15C LE? Jeff Raines 4 1,530 03-23-2012, 10:54 AM
Last Post: Jeff Raines

Forum Jump: